Tag Archives: networking issues

2016/04/21-25 (R–M) Bad Brakes & More

Leave a reply

2016/04/21 (R) More Bad Brakes

[NOTE:  There are no photos for these posts.]

We were up before 8 AM, had coffee in the living room by the warmth and glow of the fireplace, and had fruit for breakfast around 8:45 AM.  We left at 9:40 to take my car to Brighton Honda for its 110,000 mile service appointment at 10 AM.  Linda followed me in the Civic to drive me back to the house but as long as we were that close to Brighton we decided to go to the Verizon corporate store.  To our surprise, the store was permanently closed.  We were pretty sure there was still an “authorized retailer” a little farther down on Grand River Avenue (which never made any sense to me) but after the authorized retailer in Arcadia, Florida was unaware of the Mi-Fi device I was interested in (AC791L) I really wanted to talk to someone in a corporate store.

We did not investigate further as to whether the store had been moved and, not having any other business in Brighton, we headed home.  On the way I got a phone call from our State Farm insurance agent’s office about a long-term care premium that was due last month.  Apparently one of our children did not recognize it was a bill when they checked our mail and did not alert us to its presence.  It wasn’t a big deal, and Linda took care of it when we got home.

I started a load of laundry and settled in to work at my desk.  I did not have a reply yet to my support ticket for our WiFiRanger.  I checked-in to RVillage and saw that our member status had been upgraded to GOLD.  I did a search for used tractors and was researching a portable water deionizing system at AutoGeek.com when I got a call from Curtis Coleman of RVillage.  While Curtis and I were talking I got a call from Gary at Brighton Honda.  He left a message and I called him back.  The rear brake rotors and pads on my Element needed to be replaced.  It seems we have not been able catch a brake break in the last six weeks.

Linda made a haircut appointment with Renee for tomorrow at 10 AM but got a call back from Renee that she was not working tomorrow.  Renee had an opening at 1:15 PM today so Linda took that instead.  It was already noon so Linda heated a can of Amy’s Chili and we split that for lunch along with some fresh black grapes.  We left at 12:40 PM for the drive to Twelve Oaks Mall.  I went along because I wanted to stop at the corporate Verizon store in Novi.

I don’t usually go along with Linda to her haircut appointments since she now cuts my hair at home, but it was good to see Renee again.  She did a nice job with Linda’s hair and we were out of there in under 30 minutes.  For many years the Verizon store was located on the Twelve Oaks Mall property near Twelve Mile Road but it recently moved, so we put the address in the GPS unit.  The new location was nearby on Novi Road just the other side of I-96 from Twelve Oaks and West Oaks Malls.

We were assisted by Christina, who was both knowledgeable and helpful.  We went in thinking we might upgrade both of our phones and our Mi-Fi device and increase our data plan.  I was interested in the AC791L Mi-Fi device.  They did not have one in stock but she knew what it was and said we could have one delivered to our house on Monday via FedEx.  We then looked at phones and Christina steered us towards the latest offerings from Motorola.  We selected one for pricing purposes and she worked up the costs, including a higher data plan.

The new phones would have each cost $26 a month for 24 months, and the extended warranties would have been another $11 each per month for as long as we cared to pay it.  The phones had some nice features—specifically a shatterproof screen, wireless charging, and a screen-facing flash (for those all-important selfies)—but $74/month ($37 x 2) for two years seemed like a lot of money to us, especially given that our Samsung Galaxy S3 phones still work just fine.  Another negative for us is that the new phones are also bigger and we like the size of our S3’s.  Besides, I have a belt clip flip-top soft case for mine that fits nicely and works well.

Offsetting the increased phone costs was the fact that the line charges for our phones would drop from $40 per month per line to $20 per month per line.  Also, the $80 we currently pay for 10 GB of shared data per billing cycle would now buy us 12 GB of data for the same time period.  Finally, upgrading the phones would get us an additional 2 GB of data per phone per billing cycle for “life”, so our 12 GB plan would actually be 16 GB.  We would lose the bonus data, however, if we ever reduced the monthly gigabytes on our plan.

In looking at the cost worksheet I noticed that for $100 per billing cycle we could get 18 GB of shared data and bump that up or down at will without losing anything.  In the end we bought the AC791L Mi-Fi device for $90 ($100 with a $50 rebate and a $40 activation fee), changed the data plan to 18 GB for $100 (per billing cycle), and decided to keep our current phones.  Ignoring the one-time charges connected with the new Mi-Fi device we increased our monthly data from 10 GB to 18 GB, got a new/better Mi-Fi device, dropped our monthly cost from $180 to $160 (before taxes), and were not locked in to anything.  Christina also said to keep our eyes open for special deals on phones, especially around Mother’s Day and Father’s Day.  Roger that, and will do.

By the time we got back to I-96 and Grand River Avenue (GRA) in Brighton it was 3 PM so we stopped at Brighton Honda to check on my car.  While waiting for parts the technician got shifted to another job so my car was not ready yet.  Making a left out of the dealership onto GRA is always difficult and can be impossible in heavy traffic.  Our solution is often to turn right and go to Panera on GRA just south side of I-96, which is exactly what we did.  They did not have any decaf brewed but were happy to make some for us.  It had been cool and overcast all day so we sat by the gas fireplace and enjoyed several cups of coffee.

While we were sitting there I took a minute to call Philip Jarrell and let him know we were back in town.  We discussed the French drain he installed at the west end of property last fall, which seemed to be working well, and the trenching on the other side of the road, where the culvert empties, which had become a small pond.  I mentioned that the new driveway and RV pad looked nice, and that I really wanted to get the ham radio tower erected this year.  That project would require his services for a morning.  By 4:15 PM I had not heard anything further from Gary at Brighton Honda so we drove home.

Gary called at 5 PM to let me know the car was done and the technician was test driving it to make sure everything was correct.  The dealership was open until 8 PM, and we did not want to fight rush hour traffic, so Linda fixed dinner.  We had a salad of arugula and Italian kale with slivered almonds and dried cranberries, microwaved sweet potatoes, and vegan Italian sausage.  Everything was very tasty and I particularly liked the spices in the mock sausage.  Linda tries to make our diet primarily plant-based whole foods, but not having been vegans for most of our lives we find a certain satisfaction (comfort) in the occasional veggie burger, soy hotdog, seitan stroganoff, or other “mock” dish.

After dinner I hung up some laundry and started another load in the washer.  I checked e-mail and had one from my niece Amanda.  She and Ryan were looking at Wednesday, September 27, 2017 as a wedding date and wanted to know if all of us could make it to Hermann, Missouri for the event.  I replied that it would not be a problem for Linda and me and cc:d Brendan and Meghan.  I then texted both of them to alert them to the e-mail.  I also had an e-mail from Kate de Fuccio wanting to know when we expected to be back in Michigan.  I let her know we were back and had gotten preoccupied with opening the house and unloading the bus, but I felt bad that I forgot to text her as soon as we were home.

I also had a reply to my WiFiRanger support ticket requesting that I send screen shots of three of the tabs in the control panel.  I replied that I would try but did not mention that I really wasn’t sure how to do that.  Linda (the Google Queen) suggested that I “Google that” so I did.  It turns out that “alt+prtsc” captures the current window as an image and copies it to the clipboard.  From there you can do what you want with it.  Easy breezy.  (I subsequently ended up with something called “Easy Capture Manager” on my computer that just requires me to push the “prt sc” key and then lets me select what I what to capture.)

By 6:545 PM we were headed back to Brighton Honda to retrieve my car.  Linda dropped me off and returned home.  I paid the bill and returned home a few minutes later.  Thursday night is CBS comedy night and by 8 PM we were ready to just sit and laugh.  But first I had to transfer some of the laundry from the washing machine to the dryer.  I worked on blog posts while being entertained and hung up the dry laundry before going to bed.

2016/04/22 (F) Networking

I was up a little later than usual last night and would have slept in this morning but the cats had other ideas; they always do.  We were up by 8 AM and I made a pot of the Costa Rican Terrazu half-caff coffee that we bought yesterday at Teeko’s Coffee and Teas.  We were both still a little tired, and the thick fog further subdued our moods.  We countered that by treating ourselves to an easy start to our day enjoying our coffee in the living room to the warm glow of the fireplace.

We eventually got dressed, had breakfast, and got on with our day.  Linda got a call from Bill, who handles computer and networking technology for the bakery, and he walked her through the VPN setup for the bakery’s upgraded server.  She then made a grocery list and went shopping.  When she returned I discovered two boxes on the front porch.  UPS had obviously been here without my being aware of it.  The large box was the Instant Pot Linda ordered the other day and the small box was my prescriptions, which I was not expecting to see for another week.

My main focus for the afternoon was dealing with networking issues.  I uncoiled a long Cat 7 Ethernet cable that I found in the ham shack yesterday.  I unplugged the network cable for Linda’s computer from our AT&T gateway/router and plugged in one end of the Cat 7 cable in its place.  I took the other end of the cable into the bus, plugged it in to the HP Color LaserJet 3600 printer, and turned the printer on.  I brought my laptop computer upstairs, connected it wirelessly to the gateway, and tried printing a simple Word document without success.  I checked the printer settings and the TCP/IP addressing mode was configured for a manual address that did not match the address range of our home network.  I reconfigured it for DHCP and it acquired a new IP address in the correct range.  I tried printing again but it still did not work.  I reconfigured the address in the printer device properties on my computer and was finally able to print.  That was a relief as we would really like to leave this printer on the bus and have it networked rather than operating from a USB cable.

I then turned my attention to the WiFiRanger Mobile Ti (WFR-MTi).  I took my computer to the bus so I could use it to control the WFR and capture screen shots.  I was able to connect it to the WFR without difficulty but the WFR could not “see” (detect) any external Wi-Fi signals even though it is on the roof outside the bus and my computer could see them from inside the bus.  Back in the house I plugged in the Amped|Wireless SR20000G Range Extender / Router and configured it to repeat the AT&T gateway which does not broadcast a very strong signal.  Back in the bus my computer could see the strong signals from the Range Extender but the WFR still could not detect any external Wi-Fi signals.  I captured the screen shots for the MAIN, WIFI, and SETUP tabs, as requested by technical support at WiFiRanger, and pasted them into Word documents for uploading to their support system.

I took my computer back to my basement office and cabled it in to the network switch.  I wrote a reply to the WiFiRanger tech support thread, attached the screen shots, and posted it.  Clearly the WFR is not working and I am certain I will end up requesting an RMA and returning it for service, probably sooner than later, but I wanted to start with the online tech support system in case they had any good ideas that had not occurred to me.

Linda spent the afternoon getting acquainted with the Instant Pot and running it through its test procedure.  It checked out as fully functional so she used it to prepare seitan stroganoff for dinner.  I laid down at 5 PM and napped for an hour, finally getting up at 6 PM when Linda put our dinner salads on the table.  She served the stroganoff over brown rice with a side of steamed broccoli and the whole meal was wonderful.

We sat in the living room until 8 PM and then decided to watch Sleepless in Seattle on PBS.  I had forgotten what a good movie it is and enjoyed seeing it again.  Linda fell asleep right after the movie ended and I watched Episode 6 of Ken Burn’s JAZZ before calling it a night.  Like all of Ken Burn’s documentaries, JAZZ is a masterpiece of historical storytelling.  At some point I would like to watch all 10 episodes back-to-back.

2016/04/23 (S) Ham & Eggs

Today was our first Saturday back home, and that meant it was also our first opportunity to have breakfast with our fellow amateur radio operators (hams) from the South Lyon Area Amateur Radio Club (SLAARC).  Before going to sleep last night I set wake-up alarms for 7 AM this morning, but I was awake before then and had time to grab a quick shower before getting dressed.  I also took a few minutes to reattach the ham radio antenna to the magnetic mount on my car and reinstall the ICOM IC-2820 radio control head and microphone.  Even so, we were still on our way by 7:30 AM and arrived at George’s Senate Coney Island on the north edge of South Lyon around 7:50 AM.  During the drive I was part of a group chat with Steve (N8AR), Mike (W8XH), and Bill (W8NN), who was on an HT while riding with Larry (K8UT).  The Yaesu Fusion repeater sounded good and it was good to be on the air again with friends.

Besides our coffee, dry toast, and dry English muffin, Linda and I split a fresh fruit plate.  It was OK at best, but we don’t go for the food.  It was good to see and talk to folks in person and to be back into this part of our “at home” routine.  Today was testing day so a few people left to run the testing session, but most of the group, which numbered 19 people, stayed until 10 AM.

There was an accident this morning on westbound I-96 just east of the US-23 interchange.  It was still being cleared when we drove home so we got stuck in a traffic backup that could easily have been avoided.  Fortunately we did not have to be any particular place by any particular time and worked our way slowly through the congestion.

Back at the house I worked at my desk while Linda started cooking black beans in her new Instant Pot as she wanted to use some on a salad for our lunch.  Normally she would have to soak dry beans overnight and then cook them for quite a while, but the Instant Pot, which can function as a pressure cooker, took them from bag-to-plate in 45 minutes, during which time Linda went for a walk.  Pressure cookers can be very useful.

Once we got back to our house my initial task was to proofread and markup corrections to my article in the latest draft of the June 2016 issue of Bus Conversion Magazine.  Once that was done I uploaded the PDF to a folder in my Dropbox and e-mailed Gary and Jorge that it was there.  Next I checked my WiFiRanger support ticket and discovered that my reply yesterday, with screen shots attached, did not post correctly.  I replied again and this time it posted correctly, or at least appeared to.  With that task taken care of I copied a few images from the Sony a99v camera to my computer.  I then started transferring files from my computer to the NAS that we had with us in the bus.  I was about to start copying files for from that NAS to the older one we left at home when Linda called me up to lunch.

She made a large salad for each of us with tomatoes, blueberries, sliced strawberries, black beans, slivered almonds, and dried cranberries with a balsamic vinaigrette dressing.  She also made some hot tea after lunch which we took to the living room.  Both of us were tired and by 2 PM laid down and took naps.  It was 68 degrees F in the house but it felt very cool.  I think winters in Florida and Arizona have reset my comfort zone from 70 degrees F, plus or minus, to 78 degrees to 80 degrees F.  Jasper found a sunny spot on the floor by one of the living room windows and Juniper curled up with me.  I got up at 3:15 PM and took my iPad out on the deck to work in the crisp air and warm sun.  Linda came out around 3:45 PM but decided it was too cool and went back inside; I did the same around 4 PM.

Linda arranged for us to meet John and Diane Rauch at Camelia’s Mexican Restaurant at 6 PM.  Camelia’s is walking distance from our old house, but we never walked there because the route was not pedestrian friendly.  It’s a half hour drive from where we live now.  I reinstalled the cellular booster in my car and we left at 5:20 PM to leave a little extra time in case we encountered traffic problems.  And sure enough, we did.  The right lane of eastbound I-96 was closed where it ties in to southbound I-275 as the right lane continued to be closed for a construction project.

Our children’s grade school vocal music teacher, Jennifer Davidson, (who moved here from Tennessee) once remarked that Michigan only has two seasons “winter and road construction.”  Truer words were never said.  We stayed to the left, because that’s what we had to do to get onto eastbound I-696.  Although traffic was slow it was moving, unlike the right hand lanes trying to stay on I-96/I-275.  Vehicle speeds returned to “normal” once we got past the split, which around here is 5-to-10 MPH over the maximum posted limit, and a few minutes later we exited the freeway at Orchard Lake Road.  This is the same exit we used for 35 years to get to our house, and I have undoubtedly used this exit more than any other Interstate highway exit in country.  It was familiar, yet strange, as we rarely get back here anymore except to visit with John and Diane, meet someone at Camelia’s (or one of the other many restaurants that can be accessed from the Orchard Lake Road exit), or go to our optometrist or veterinarian, both of whom are two to three miles south of this exit.

We had our fill of chips and salsa and split an order of vegetarian fajitas.  They were OK, and much better than the ones we had a week ago at Mi Camino Real in Logansport, Indiana.  After dinner we went to John and Diane’s house, which is very close to the restaurant, and continued a nice conversation in a quieter setting.  By 9:30 PM we were all tired and started wrapping up our visit.  We left a little before 10 PM, got home at 10:30 PM, and went right to bed on stomachs that were still very full.  WTVS (Detroit PBS) was fundraising around an early Rolling Stones performance that did not grab my interest so I watched Lidia’s Kitchen and the beginning of Martha Stewart’s Cooking school.  She was filleting fish so I turned the TV off and went to sleep.

2016/04/24 (N) Family

We went to bed on full stomachs last night and I did not sleep well, suffering from indigestion for much of the night.  I should have used a second pillow and tried sleeping on my back with my head elevated, but that is not a natural sleeping position for me and I doubt that would have slept any better.  To compensate for the poor sleep I stayed in bed and kept falling back to sleep.  Linda was up way before me, having apparently slept better than I did, and I finally got up to stay at 9 AM.  That was unusually late for me, but at least I felt somewhat rested.

As soon as I got up Linda sliced oranges for our breakfast and prepared to toast bagels while I prepared our morning coffee.  We were not quite done with our preparations when I got a phone call.  It was from Chuck Spera so I answered it.

Chuck and I talk frequently but not usually at 9:30 AM on a Sunday morning.  He and Barbara were on the road and had just crossed into Kentucky on I-75 having left Sevierville, Tennessee early this morning.  Before pulling out this morning Chuck had noticed a little oil by the driver side tag axle during his walkaround, specifically in the holes of the Alcoa aluminum wheels.  He had removed the decorative hub cap and found an oil film there as well, but did not see any pooling.  He assumed that an axle seal was leaking a little but was not sure how to check the oil level in the hub or add oil if needed.  Because of both past and recent experiences, Chuck figured I would know the answers to both questions.  While that was probably unjustified optimism, in this case I did, and gladly shared what I knew about the sight glass and rubber plug in the wheel hub for the oil reservoir.

We had just finished our bagels and orange slices when Brendan texted Linda to see about plans for today.  We had all planned on getting together at Meghan and Chris’ house this afternoon to visit and have dinner but Madeline had come down with Hand, Foot, & Mouth disease (a virus) earlier in the week and Brendan thought he might be getting it too.  Given that Linda had not yet fully recovered her hearing we agreed that it would be best to avoid contact until we knew that no one was contagious.

Madeline was understandably disappointed that she would not see us today and, in lieu of that, requested a FaceTime session.  We were equally disappointed that we would not get to see her (and her parents) but an hour of FaceTime made up for it a bit.  After our FaceTime session we lingered in the living room by the fireplace enjoying our coffee and doodling on our iPads.  We finally got dressed at noon and left for Meghan and Chris’ house at 12:30 PM.

We arrived around 1:15 PM and were greeted by our daughter with a paper grocery bag full of some of our mail.  We had a long, relaxed afternoon to visit and catch up.  Meghan made vegan burgers from scratch and a salad with beans, corn, red bell pepper, and avocado with a lime-based dressing.  We brought a bottle of Barefoot Red Moscato and I found it very much to my taste (sweet).

We departed just after 7 PM and stopped at the new Gas 2 Go station at the northwest corner of I-96 and Latson Road.  The station was still under construction when we left in November.  I was pleased to see that it is a Shell Oil Company station with a Tim Horton’s.  I have had a preference for Shell gasoline for most of my adult life and Tim Horton’s has coffee on a par with Dunkin Donuts, although I do not like the lids they use.  There is also a traffic signal on Latson at the side road for the station, no doubt because this is also the access road for the Livingston County Road Commission complex.  (Leave it to them to take care of themselves while the rest of rest life and limb to get out of the Lowe’s/Walmart center just south of there.)  Whatever the reason, it will slow down traffic exiting I-96 and heading south on Latson Road, making it easier to get out of the Lowe’s/Walmart parking lots.

We were home a little after 8 PM and turned on the TV to watch Grantchester on PBS and Elementary on CBS.  Around 8:40 PM I realized I had missed the SLAARC Information Net which started at 8 PM.  I need to reestablish the habit of tuning in on Sunday evenings, but that time slot competes with some of our favorite programming on PBS.

2016/04/25 (M) Pick Up Sticks

We had a typical start to our day.  After catching the weather on channel 10.2 we were up by 8 AM, had coffee and granola with blueberries and bananas, and used our iPads in the living room with the fireplace turned on.  Our Kitchen Aid mixer broke last year and today Linda was finally ready to replace it.  She decided to get the slightly larger and more powerful model with the crank up mixing bowl as she wants enough power to mix bread dough.  She also wanted it in white to match most of the other kitchen appliances.  To our surprise the white color was more expensive than red or blue but less expensive than some other colors including copper bronze.  She was trying to convince herself that red or blue would be OK but I convinced her to order white.  All of our appliances (and cabinet knobs) are white.  With Amazon Prime it will be here on Wednesday.

The weather forecast was calling for a cold front to move through our area triggering rain, and possibly thunderstorms, starting late in the afternoon and extending through the evening and into the overnight hours.  The grass in most of the yard is not very tall yet, except right in front of the house by the concrete driveway.  The yard is also moist, but not soggy, and we do not expect Keith to be here to cut the grass for the first time this season until sometime next week at the earliest.  The temperature mid-morning was in the low 60’s and was forecast to reach a high of 72.  All-in-all it was an excellent day to pick up sticks around the yard in advance of Keith’s first visit and get the Honda self-propelled lawn mower out and cut the grass in front of the house.

I started my yard cleanup with area around the front berms, raking small branches out of the grass and stacking larger ones on existing brush piles.  While I was working out front a UPS truck showed up with our Max Burton Induction Cooktop and our new Verizon Mi-Fi unit.  I signed for the Mi-Fi and took the packages inside.  Linda used the induction cooker to make some nectar for our hummingbird feeder and also prepared a batch of homemade granola.  She eventually came outside and helped me pick up some of the downed tree limbs in the back yard.  We got the easternmost two acres (2/5ths of our yard) picked fairly well.  We will work on the westernmost three acres another day.

I got the Honda lawnmower out and topped up the tank with fresh fuel.  Small engine Honda equipment is known for starting on the first pull, but my experience is that this is only true when they are new.  No doubt our lawnmower needs to be cleaned up and tuned up, and would start more easily if it was, but I eventually got it started and once it warmed up it ran fine.  I mowed the little bit of the lawn near the house/driveway that looked like it was overdue for a cut.  This is also one of the only parts of the yard anyone really sees if they pull into the driveway.

I had just shut the lawnmower off and was putting it in the garage when the U. S. Mail truck pulled into the driveway.  It was our mail carrier, Michelle, and she had a very large box for us, along with our typical bundle of Monday junk mail.  The box was not very heavy and Linda informed me that it was the 48 rolls of toilet paper she recently ordered.  Well, alrighty then.

It was approaching 1 PM so Linda made salads for our lunch with the leftover bean-corn-tomato salad (that Meghan made yesterday) on top of a bed of mixed greens.  After lunch Linda took her Amateur Extra flash cards outside to study and I focused on getting the new Verizon Jetpack Mi-Fi (Netgear AC791L) assembled and activated.  Assembly consisted of installing the Lithium Ion battery and back cover.  I decided to charge it for a bit while I read the user guide and activation procedure.

When I was fairly certain I had all of the information I needed at my fingertips I called the 877 activation number and keyed in the requested information.  It took a couple of tries to get it right but I finally did.  With the activation completed I turned the device on, looked up the SSID and Password, and connected my iPad to it.  I then entered the relevant information in a new entry in Passwords Plus.

I got a phone call from Gaye Young and chatted with her at some length about RVillage and its relevance to FMCA.  (Gaye is the FMCA National Secretary and chairperson of the National Education Committee.).   She and husband Jerry are at the Rally in the Pasture at FMCA National President Charlie Adcock’s place in Arkansas (or maybe it’s Alabama?) and I knew from talking to Curtis Coleman last week that he was on his way there too.  A year and a half ago the NEC researched and recommended that FMCA partner with RVillage and a year ago the FMCA executive board accepted and endorsed that proposal but then nothing happened.  The FMCA Executive Director was recently let go and Charlie is now trying to get the RVillage train back on the tracks, along with lots of other things as FMCA continues to loose members at an alarming rate.

I suspect that the loss of members is a combination of several factors.  For one, the median age of FMCA members has been in the upper 60’s for quite some time.  That means a certain number of members are “aging out” almost daily.  For another, the downturn in the economy in 2007 was particular hard on the RV industry.  Not only was the industry slow to recover, when it did it was building mostly towables, not motorhomes.  In the past many RV dealers basically “included” an FMCA membership with the purchase of a motorhome, or at least provided information about the Association and an application form.  Another possible factor is that RVers under 50, including Gen-Xers and Millennials, don’t tend to join things.  FMCA is not the only organization suffering membership decline and having difficulty attracting new members, especially younger ones.

Chuck and Barbara got home yesterday and were settled enough for Chuck to call me at 5 PM and update me on their hub oil leak.  Linda made salads for dinner and reheated the brown rice and seitan stroganoff.  After dinner I replied to an e-mail from Gaye and then settled in to watch TV with Linda.  And so it goes.

 

2016/04/11–15 (M–F) Water Pumps on the Road Again

1 Reply

2016/04/11 (M) Parts Run

I was up at 7:30 AM, so I slept over seven hours last night, and felt like I had slept well enough to take on the day I had ahead of me.  I fed the cars, put fresh water in their bowl, and cleaned their litter tray.  I also cleaned part of the shower as one of them has developed loose stools in the last couple of days and has not always made it to the tray in time.  I moved the SunPass transponder, Garmin GPS, and my sunglasses to the car in preparation for my trip today.  By the time I had done all those chores Linda was up and both used our iPads for a while.  I was not going to make coffee this morning since I had a long drive ahead of me sometime today, but Linda wanted some so I made it and had some myself.  We eventually had bagels for breakfast.

I called Action Mobile around 9 AM and talked to Service Manager John Provo.  He expected my three brake calipers to be delivered between 10 AM and noon but that was just a guess on his part.  Rather than make an issue of getting a more accurate ETA I decided I would leave at 10 AM for the two hour drive from Williston to Orlando.  I went out after breakfast and unloaded most of the stuff in the back of the car and stored it on the picnic table.  I then walked to the resort office to let them know we were expecting a package from Amazon today.

Just before 10 AM I wrote out a short grocery list as I planned to stop on my way back from Orlando at The Publix supermarket on US-27 by the Ocala exit (#354) of I-75.  I took my iPad in case I needed to kill some time at Action Mobile, and actually left a little after 10 AM.

The trip down was smooth, with no traffic issues, and it was uneventful except for a text message from my sister asking me to call our broker and transfer funds for our dad.  Based on when I received it the best I could do was pull into one the Florida Turnpike Service Areas closest to Orlando’s northwest corner and call the brokerage.  The person I needed to speak to (Maggie) was on another call and I did not want to deal with a return call while driving so I left a message that I would call again when I got to my destination, which was still 20 minutes away barring any unforeseen traffic problems.

Traffic was thicker and a little slower as I neared Orlando but it moved along well enough and I reached Action Mobile just after noon.  I called Maggie again and got her this time as she is in the Central Time Zone.  Maggie is our broker’s office manager and is also a registered agent.  We have an extremely good relationship with her and our broker, John, so we chatted briefly before I gave her the transaction details.  I then texted my sister back to let her know I had taken care of her request.

I went inside and found John P. (the Service Manager).  The parts were not there yet so he called Rex at Rush Trucking to check on them.  Rex said they should have been there and made a call.  Not too long after that a white can showed up and the driver unloaded three Meritor boxes of the right size, shape, and apparent weight, and took off.

It occurred to me that I should check the parts before paying the balance and taking off myself so I opened all three boxes.  I was expecting one of the castings to have an “L” in the casting number and the other two to have an “R” in the casting number, but all three had “L”s and that caused me some concern.  I also noticed that one of the calipers had both grease fittings broken.  John P. called Rex back and Rex explained the Left and Right calipers used the same (“L”) casting.  The difference was in the helical drive shaft and gear inside, and difference was reflected in the part number on the box label.  The left side caliper part number began with “A 1” while the right side caliper began with “A 2.”   (The shaft for the calipers on the left side of the bus rotate clockwise, as viewed from the end where the slack adjuster attaches, while the calipers for the right side rotate counterclockwise.)

Rather than have Action Mobile remove and replace the damaged grease fittings Rex had a different left caliper sent over as he did not want to risk a small piece of debris falling inside the mechanism.  When the driver dropped it off I checked the label and the grease fittings.  There were OK, so he put the damaged one in his van and left.

While I was waiting I called Butch and gave him the information on how the left and right calipers were labeled.  He is working with someone at ABC Bus in Muncie, Indiana, who is working with someone at Rockwell-Meritor, who says we can still get these parts with a 45 to 60 day lead time.  I’m guessing that these are also rebuilt/remanufactured calipers, not new ones, but at this point in time we don’t really know.  He was quoted a price that was $200 less per caliper than I paid, but I have mine now, not two months from now; if in fact I could get them.

Bill, the mechanic who fixed our left tag axle brake last week, was taking his lunch break so we got to chat a bit.  John D. (the owner) was also around so we also got to chat for a little while.  I was running behind the schedule I had hoped to keep, so I loaded the three boxes into my car and went inside to pay the balance of the bill.  A quick chat with the billing clerk, Lisa, and I was on my way back to Williston.  It was 1:30 PM and I figured I would be back by 4 PM, including my stop at Publix.

I stopped at the Florida’s Turnpike Turkey Lake Service Area for some lunch but just ended up getting a frozen coffee thing at Dunkin Donuts.  Traffic moved along nicely all the way onto northbound I-75.  I had just passed exit 341 and was just 13 miles short of exit 354, when traffic came to a complete standstill.  The backup stretched as far as I could see in front of me and the flurry of emergency response vehicles driving up both shoulders meant there had been a serious accident somewhere up ahead.

It took at least an hour to reach the accident scene, where police had closed all three lanes of the highway.  All of that of traffic, which included two lanes of nose-to-tail tractor-trailers, had to funnel onto the right shoulder to get around the blockage.  The accident looked really bad and appeared to have involved at least a motorcycle, a large Suburban-like vehicle, and a utility trailer.  There may have been other vehicles involved that I did not see as I drove past or that had already been moved, although I doubted that.  There was no sign of the people involved and I presume they had already been transported from the scene by ambulances or helicopters.

Once I was past the accident I had clear sailing the rest of the way, but from the accident scene north the southbound lanes of I-75 were also completely stopped.  There were also emergency vehicles on the southbound side of the highway, but it did not appear that any of the accident was over there.  I exited I-75 at exit 354 (Ocala, Williston), made a left onto US-27, and pulled into the strip mall on the right where the Publix supermarket is located.

I took my short list of grocery items and went in.  In an unusual move for me I found everything on my list except for one item and did not buy anything that wasn’t on my list.  The only thing I could not get was fresh blueberries, which is odd because just today I had seen billboards advertising the Florida Blueberry Festival as running from April 11 – 16 in a town nearby.  Maybe all of the available blueberries were being routed to the festival?

I was back at our rig around 5:10 PM.  After getting the groceries inside, I turned my attention to reloading the car.  My first task was to transfer the new (to me) A1/Left caliper to the box the DS tag axle caliper came in last week as the box the new caliper came in was in very bad condition.  Linda found our roll of bubble wrap under the bed and I used pieces to protect the grease fittings on the top of each of the three new (to me) calipers.  (I say “new (to me)” because I believe the four calipers I have purchased are all rebuilt, and possibly even remanufactured.)

With that taken care of, I moved a couple of low boxes from the picnic table to the car and put them on the floor behind the two calipers that were behind the driver’s seat.  I then moved the tire covers from the front passenger seat and put them on top of the boxes.  The covers are a soft nylon mesh material which I figured would provide additional protection for the grease fittings.

We disassembled the damaged box to get flat cardboard pieces to use as a cushioning layer on top of the two caliper boxes that I had put inside the wooden storage structure.  The reason for all of this was that I had to store other boxes on top of the caliper boxes and, having received one that had damaged grease fittings, wanted to make sure I was not responsible for causing similar damage.  I had already taken the precaution yesterday of moving heavier items to the front bay of the bus, leaving lighter items for the car.

With the car repacked I opened the box from Amazon, which Linda said arrived around 10:30 AM, to verify that it was the correct Shur-Flo 4048 fresh water pump.  It was the correct box so I left it at that and we went for a long, slow walk around the resort.  When we concluded our walk we sat outside for a while and doodled on our iPads.  John and Ali returned around 6:30 PM.  As we suspected, they had gone out to dinner.  We presumed they had gone to The Blue Highway, but they had gone to The Olive Garden in Gainesville instead.

For dinner Linda made sandwiches with vegan deli slices and lots of greens, kind of like a salad on a bun, and sliced up a Honey Crisp apple.  It was a simple, easy meal, but it was all good.  As the hour approached 8 PM and the light faded we went next door to visit with John and Ali.  Earlier in the day John had taken one of his propane tanks over to be refilled but the person responsible for that task had not taken care of it.  When he tried to light the propane firepit it would not ignite.  We could smell the gas, and hear the spark, but if the tank was near empty it probably did not have enough pressure to make it work.  No problem; the conversation, if not the “mood,” was just as good without the fire.

It was a warm, still evening and there were more bugs out than the last few nights.  Everyone was tired by 10 PM and we all retired to our own rigs.  We watched the end of NCIS-LA and the beginning of the news and then went to bed.  I watched the beginning of The Late Show with Stephen Colbert to see Steve Martin and Edie Brickel, and then went to sleep.  Although I had not really done very much it had been another long, and somewhat stressful, day.

2016/04/12 (T) Water Pump Up

I got up at 7:30 AM and quietly took care of the cats’ food, water, and litter tray.  I measured out the beans for our morning coffee but waited to grind them until Linda was up.  I updated my spreadsheet for GLCC parking at the upcoming FMCA GLAMARAMA16 rally in June and then continued working on my blog post for yesterday.  When Linda got up at 8 AM I finished making the coffee.  We then spent a couple of hours engaged in our usual morning routine of using our iPads while enjoying our coffee and having granola with fresh strawberries for breakfast.

By 10 AM we were dressed and I got to work replacing the fresh water pump.  The pump is a Shur-Flo 4048-153-E75.  It is a 4 GPM (max), 55 PSI (max), self-priming, 12 VDC pump with thermal overload protection and the ability to run dry without damage (although our friends, Butch and Fonda, discovered that it cannot do this for an extended period of time).  Shurflo also makes this pump in 24 VDC and 120 VAC versions.  I am seriously considering adding a 120 VAC pump to the water system when I redo the utility bay, but I would like something a bit more robust.  I seem to recall that Chuck has a Paragon AC powered pump in their Liberty conversion and it impressed me as a very serious piece of equipment.

Since the new water pump was an exact replacement for the failed one installation was very straightforward.  I shut off the incoming fresh water line as a precaution and had Linda make sure the pump power was switched off.  I then disconnected the two power leads which I had wired using mating insulated spade connectors.  There are two fresh water supply lines, each of which gas a 1/4 turn shutoff valve, so I closed those.  (The conversion had two domestic water pumps plumbed in parallel when we first bought it.  I replaced them with a single 4048 and removed the surge tank at that time as Shur-Flo recommended not using one with the 4048 pump.)  The threaded water line connections to the pump are plastic and only hand tightened, so were dealt with easily.  Before removing them I got a towel to absorb the water that was inevitably going to drain out of the lines.  Once the lines were off I removed the four screws that secured the unit to the floor through the rubber shock mounts.  The unit was now completely disconnected and I was able to remove it.

The new and old water pumps along with tool boxes and other stuff needed to make the repair.

Installing the new unit was basically a matter of reversing the steps just described, more or less.  I  needed to attach the proper insulated spade connectors to the power wires on the new pump.  I found my spade lug kit and even though I had a variety of connectors I did not have the ones I needed.  Fortunately there is a NAPA Auto Parts Store very close to Williston Crossings RV Resort and auto parts stores are an excellent place to find a large variety of spade connectors.  It’s walking distance to the store, but I drove there to save time.  I bought several different packs to make sure I had what I needed.

Back at the bus I prepared the power leads and set the new unit in place.  I connected the water lines first as it was easier with the unit loose.  I connected the power leads and then screwed the unit to the floor.  The new pump came with a strainer and adapter fittings.  I used the new strainer bowl to replace the old one, in which I found little curly queues of plastic.  I opened the two shutoff valves and then had Linda turn on the power to the pump and open the kitchen faucet so that both the hot and cold lines were open.  The unit came to life and water flowed, albeit with a sputter until all of the air was out of the lines.  With that, the water pump problem was fixed and I cleaned up the work area and put my tools away.

Next on my task list was checking tire pressures.  I really did not want to check all 12 tires with the digital gauge so I turned on the TireTraker TT-400 TPMS and waited 20 minutes for the readings to update.  Although the sensors are not “dead on” accurate they are close enough to let me know if a tire has lost enough air to require topping up.  They all appeared to be OK so I did not have to get out the air-compressor and air hose.

Barring any further unforeseen circumstances this was our last planned night in Florida for the 2015-16 winter season.  We wanted to go to Satchel’s in Gainesville for pizza one last time.  We decided to have an early dinner and take care of a couple of errands so we left at 2 PM.  Our first stop was at the Kangaroo filling station for gasoline.  Our next stop was Pet Supplies Plus in the Archer Road mega strip mall shopping complex.  We also stopped at the CVS pharmacy in the same complex and then drove to Satchel’s on the east side of town.

Although it was a lovely afternoon, weather wise, we chose to sit inside.  At Satchel’s we had our usual meal; an excellent salad and a pizza with mushroom, onion, sun-dried tomato, and Daiya non-dairy cheese.  It is, quite simply, one of the three or four best pizzas we have ever had, and it is vegan!  We got their largest pie and brought most of it home.

When we got back to Williston Crossings John and Ali were not around and we figured they had gone out to dinner again.  Happy hour usually takes place at Jeff and Kathy’s 5th wheel so we walked down there to visit for a while.  John and Ali eventually returned and as evening fell over the resort we went next door to sit around their propane campfire and visit.  Smitty made a large bowl of popcorn popped in peanut oil and lightly salted with Hawaiian sea salt.  Yum. Note for T 20160412 blog post.  Jim and Janet Rawley came over to John and Ali’s site to visit and John played his guitar and sang for a while.  Jim’s professional name is “Sonny Fox” and he was a big time rock ‘n roll D. J. during the ear when radio stations started playing “album rock.”  Jim quizzed me about my musical background and the first record (45 or LP) that I bought but I had no recollection of that.

We returned to our rig just before 10 PM and were in bed, with the lights out, by 10:30 as we planned to pull out of our site around 7 AM in the morning.  Tomorrow we head north and leave Florida.

2016/04/13 (W) Unbalanced Travel

I set an alarm for 6:20 AM and we got up at 6:30 and got dressed.  Today was a travel day so we did not have coffee or breakfast.  While we prepared the interior of the coach for travel I encountered a problem with the 12 VDC charging plug for the Rand McNally TripMaker RVND 7710 GPS unit.  A small threaded plastic insert, which holds the spring-loaded +12V center contact, had broken and could not be repaired on short notice (if at all).  The two lower 12 VDC “cigarette lighter” outlets were dead again and it occurred to me that the failed plug might have been responsible for shorting the outlet and blowing the supply fuse last Wednesday.  Not realizing this at the time, and desperate to get the GPS back into service, I vaguely recall having plugged it into one of the upper outlets and probably shorted it out too.  I replaced all of the blown fuses last Wednesday but did not realize at that time what the root cause was and was rather perplexed by the failure, which reoccurred on the lower pair of outlets.

I removed the R-M GPS from its usual mounting position (on the driver side lower windshield next to the center pillar and resting on the top of the dashboard cover) and set it aside and I installed the Garmin 465T GPS unit in its place.  I took care of the remaining outside tasks of disconnecting/storing the shorepower cord, connecting the chassis batteries, and opening the auxiliary air supply valve for the engine accessories.  Linda moved the car to another site so it was out of the way as I started the bus motor and aired up the chassis (brakes and suspension).  She then spotted for clearance from obstructions as I slowly and carefully pulled out of our site.

We wanted to be on the road at 7 AM but it was about 10 minutes past the hour when I finally pulled out of the site.  Our friend and neighbor, John (Smitty) Smith, was up and outside to wave goodbye, which was nice.  I proceeded north through the resort on Covered Bridge Road and Linda followed in the car.  We drove through the covered bridge, for which the road is named, and stopped just short of the north bath/laundry building to hook up the car for towing.  There are no park model trailers or RV sites close to this location, so we knew we could hookup here without bothering anyone.  With the car attached we double checked the settings and then did our light check.  Everything was OK so Linda got into the coach and we set our destination in the Garmin GPS unit.

We finished our slow roll through the RV resort, out the back/northwest gate, and pulled out onto FL-121 headed northeast towards Gainesville.  About two miles from I-75 we encountered stop-n-go traffic.  The morning rush hour in Gainesville was underway and was something we had not previously experienced.

Linda kept a close eye on our tire pressures and temperatures, especially the driver side tag axle, as we rolled along.  We stopped at the Pilot station at Exit 460 and took on 60 gallons of diesel fuel.  That was our last stop until we got to the end of our trip for the day.  I would have liked to note here that the trip was uneventful but, alas, that was not the case.

The drive up I-75 through northern Florida and southern Georgia is generally an easy one, without any serious grades to climb or descend, attractive enough scenery, and reasonable traffic volumes except during the April 1st northward snowboard migration.  As we got to the Macon, Georgia area and then on up to Atlanta, traffic was heavier but moved along.  Somewhere along the way the Battery Balance (BAL) light came on, flickering at first but then staying on.  Not good.

The Battery Balance light is controlled by a Vanner Battery Monitor Module and is supposed to indicate that the “12V” center tap on the battery bank is not within +/- 0.75 VDC of 1/2 of the voltage between the “24V” terminal and ground.  The relationship of these voltages is supposed to be regulated by a pair of Vanner Voltmaster Battery Equalizers.  It is normal for this light to come on occasionally, especially when starting the motor, but it is not normal for it to come on and stay on.  Assuming the monitor module is not defective, it means the 12V center tap is out of tolerance with respect to the 24V terminal and implies that the Vanner equalizers are not doing their job.  Ugh.

Having the yellow Battery Balance (caution) light come on immediately added stress to the trip but when the red Hi/Low Battery (warning) light came on the stress level went way up.  This light is also controlled by the Vanner Battery Monitor Module and is (supposed to be) activated if the voltage at the “24V” terminal (relative to ground) is less than 24V or more than 30V.  Voltages outside the 24 – 30 VDC range could indicate a malfunction of the voltage regulator and/or engine-mounted alternator.  Either one would be a problem that could put the bus on the side of the road as the engine is controlled by a computer that is powered by the chassis battery 12 V center tap.

The normal full-charge resting voltage of a “24V” lead-acid battery is 25.2 VDC (12 cells in series at 2.1 volts per cell) and the normal voltage at the 24V terminal with the motor running is around 28 VDC, so the 24 – 30 VDC range is a reasonable one. I also have 24V and 12V analog battery voltage gauges in the dashboard that are connected to the batteries independent of the Vanner Battery Voltage Monitor Module.  While they would also show high or low voltage conditions, and, by comparison, a battery imbalance condition, it is appropriate to have warning lights to get your immediate attention as you might not notice the gauges for a while.  What was odd about this situation was that the 24V gauge was sitting at about the 29V position and the 12V gauge was sitting at about the 14V position.  I knew these gauges worked because they do not always show these readings, but I did not know if the readings were accurate.  They are, however, close to what I normally see, and they do not usually result in caution or warning lights.

We left I-75 (GA) at exit 296, Cassville-White Road, drove 0.2 miles east to the Pilot truck stop, and got in a long to wait for a pump.  When it was finally our turn I added 92 gallons of diesel fuel.  From the truck stop we drove west back towards I-75 and continued 0.5 miles on the other side of the highway before turning left into the Cartersville Castle-White KOA.  Linda was hearing and speaking well enough by now to be able to register us, which is normally her job.  We were escorted to a water/electric pull-through site in the center of the park with less than ideal access but I was able to get in and park the bus.  We leveled as best we could, shut off the engine, batteries, and air and then plugged in the shorepower and turned it on.

Linda made a really good salad for dinner and we each had a piece of leftover pizza, slightly warmed.  Yum.  After dinner I made calls to Joe Cannarozzi, Ed Roelle, and Butch Williams and sent a text to Pat and Vickie Lintner.  Joe was working on a coach in Williamston, Michigan and was looking for a local facility that could service the over-the-road air-conditioning system.  Ed has been around converted buses in Michigan for a long time so I contacted him to see if he had any suggestions for Joe.  We went for a long walk around the campground during which I had a long chat with my sister.  When we got back to our coach I exchanged text messages with Smitty back at Willison Crossings RV Resort.

Our TV options were limited but we were able to get PBS, so we watched whatever was on.  We planned to pullout out of our site at 7 AM, which meant we had to be up around 6:15.  Not that we have that much to do, but we do not like to rush through our morning routine.  We were in bed with the lights out by 11 PM.

2016/04/14 (R) A Relatively Smooth Run

There was a possibility of rain last night so we closed all of the roof vents and narrowed the window openings before we went to bed.  I set the alarm on my phone last night for 6:15 AM this morning, but I was aware of the rain, and woke up around 4 AM when I heard one of the cats making a strange noise.  I wanted to turn on the electric engine block heater anyway so I got up and did that, checked on the cats (they were fine), and went back to bed.  I tried to go back to sleep without complete success.

We finally got up to stay at 6:30 AM and got dressed.  I had an e-mail from Gary at BCM that needed a reply and cc:d Dave Aungier.  I also texted Dave as he was who Gary needed to contact.  I shut down all of the technology and packed up my computer while Linda cleaned off counters and secured windows.  The car was already connected for towing so we just had to go through the towing procedure and double check it.  I disconnected and stowed the shorepower cable, connected the chassis batteries, and opened the air valves in the engine bay.  I started the engine and we did the light check while the chassis aired up.  Since it was 7 AM we tried to avoid idling any longer than necessary before pulling out.

We were in an angled water/electric site in the middle of the campground with fairly tight ingress and egress.  I raised the tag axle so shorten the turning radius and pulled out while Linda kept an eye on the driver side front corner.  I had to get the driver side nose of our coach fairly close the passenger side rear corner of the 5th wheel trailer directly in front of our site in order to get our passenger side rear end and toad to clear a tree on our site and a post near the road on the next site to our passenger side.  I also had to avoid the rear end of the next 5th wheel trailer and the picnic table in-between them.  Fun.

Without being over-confident, I think I have gotten a lot better at maneuvering the bus in tight situations.  That skill has come with some good teaching, some practice, and at the expense of two mistakes that caused some damage, but it certainly paid off this morning.  Once I was cleanly out of our site and into the road I stopped and put the tag axle down.  Linda got on board and we rolled slowly out of the center of the campground and headed for the exit.  We stopped before exiting so Linda could find Juniper.  We knew she was onboard, but we wanted visual confirmation before pulling out.  Linda found her under one of the living room captain’s chairs, and we were on our way.

We recharged the Rand-McNally GPS last night using a 12 V car outlet splitter with USB ports and a compatible USB cable that I borrowed from the Sony a99v DSLT camera.  Linda turned it on and entered the address of today’s destination to verify that the unit was working.  It was, so I set it up on the dashboard by the windshield center pillar so it was ready to go this morning.

Our route took us north on the final 70 miles of I-75 in Georgia to Chattanooga, Tennessee where we headed northwest on I-24.  I-24 was mostly in Tennessee, but dipped back into Georgia briefly as it swung around the southern side of a mountain.  Unless you head far to the west on I-10 before turning north, there isn’t a practical way to get back to Michigan from Florida without crossing mountains.

As you head north from Florida on I-75 the ground rises steadily.  As you approach Atlanta it starts to get hilly, and that continues north of town all the way to Tennessee.  As soon as you head west on I-24 you are perpendicular to mountain ridges running SW to NE.  The highway winds around these ranges, sticking to valleys as much as possible, but inevitably there comes a point where it simply has to go over the top.  And so it did.  I think the grade was at least five miles long, perhaps seven, with lots of turns but nothing I would call a switchback.  The road surface was excellent with wide lanes and truck lanes.  The grade was just steep enough that I had to climb it in 4th gear doing around 50 MPH at 2000 RPM with 14 to 15 PSI of turbo boost.  With cool outside air the engine coolant temperature never rose above 195 degrees F, which is its normal operating temperature (on the gauge) and I was very pleased with the way the bus ran.  Replacing the turbo boost sensor tube last year was no doubt partly responsible for this performance.

The temperature was in the low 50’s when we left the Cartersville Castle-White KOA around 7:15 AM and we ran through cool temperatures under overcast skies, with intermittent drizzle and fog, all the way over the mountains in southwest Tennessee.  Once we were on the northwest side of the mountains the cloud cover started to break up and reveal patches of blue sky.  Somewhere southeast of Nashville we encountered our last raindrops and by the time we merged onto northbound I-65 we had clear, blue skies.  Traveling “north” from late morning to early afternoon we had the sun at our backs, making for a comfortable cockpit without using the air-conditioning.

I was concerned about the issue we had yesterday with the Battery Balance (BAL) telltale caution light and the Hi/Low Battery (Voltage) telltale warning light and presumed it would reoccur today.  In order to reduce the chance of that happening again today I tried to minimize the power draw from the +12 VDC center tap of the chassis batteries and perhaps cause an imbalance between the upper and lower halves of the battery bank.   To that end I did not use the cockpit HVAC fan and kept the headlights off as much as possible.

We had a pretty smooth run all the way to and through Nashville.  Pat and Vickie had alerted us to “construction on I-65” but were not more specific.  North of Nashville we encountered a major construction project that lasted for at least 20 miles.  Traffic flow, however, was very smooth if a bit slower than normal posted speeds.  As we approached Louisville we saw signs announcing major construction ahead and advising I-283W as an alternate route.  We were less than 15 miles from our destination and needed to take the second exit just after the bridge so we rejected the alternate route suggestion and stayed on I-65.  The construction was, indeed, major—the reconstruction of a bridge over the Ohio River—but we made it through without having to stop.  The campground website had very specific and detailed directions on how to exit I-65 and we followed them instead of the GPS.  We were momentarily confused after exiting, never a good thing when driving a bus in an urban area, but we were in the right place and made the last couple of turns to get to the Clarksville KOA campground without difficulty.

Linda checked in at the office and the woman at the desk lead us to a pull-through site that was very easy to get into but might be challenging to exit in the morning.  We were sitting level without having to adjust anything so I shut off the engine and we went through our usual arrival routines.  Linda then walked over to the office and finished registering us.

We walked the park, which was not large, and scoped out our departure route and any possible problems.  The sites here are closely spaced, the roads are a little narrow, and some campers are parked with their vehicles sticking part way out into the road.  Some of the people camped here appeared to be younger men who were itinerant workers.  As such, we suspected they might be gone in their cars before we pulled out in the morning.  If so, we will probably get out OK without having to unhook the car, but I doubt that we will ever return here.  While the location is convenient to I-65 and Louisville, the park itself is not worth the $50 a night they charge.  If not for the location, it wouldn’t be worth half of that.

We did not plan to unhook the car to explore the area and there did not appear to be anywhere to walk although Vickie had texted us that we were only a half mile from the river and there was, in fact, a nice walk down to there.  Even so, we were tired and perfectly content to retire to our coach, have dinner, and watch our favorite Thursday evening CBS comedy shows.  We went to bed at 11 PM as we planned to be on the road at 7 AM so we could be at Butch and Fonda’s home in Twelve Mile, Indiana before noon.

2016/04/15 (F) Back In Twelve Mile Again

I set the alarm on my smartphone last night for 6:30 AM this morning.  Like last night, I woke up around 4 AM, turned on the engine block heater (electrical), and tried to go back to sleep.  I was awake again before 6:30 and the alarm was just my signal to actually get out of bed and get dressed.  Linda woke up with the alarm and was also up and dressed fairly quickly.

As usual for a travel day, we did not make coffee or have breakfast and instead set about preparing the coach for travel.  I had turned off my computer last night so all I had to do was pack it up.   We also left the car and bus connected together, so all we had do was check the connections and go through the towing procedure.  I turned the block heater and Aqua-Hot electric heating element off, disconnected the shorepower cord and stowed it, opened the auxiliary air supply valves, and started the main engine.  We did a light check while the chassis aired up and then Linda climbed aboard.

I was concerned about getting our rig out of the small, tight site and through the narrow interior gravel roads of the campground, but our neighbor’s to the left moved their truck before they went to bed last night and the guy directly in front of us on the other side of the street left in his car just before 7 AM, presumably to go to work.  That meant I had plenty of space to pull forward and to turn to the left, which is the direction the site was angled.  By 7:25 AM we were exiting the park and on our way to Twelve Mile, Indiana.

Although we had less than 200 miles to travel today, I-65 continued to be one long construction zone with lots of very rough surfaces which made for more difficult and tiring driving.  In-between Clarksville and Twelve Mile was Indianapolis, so that meant major urban traffic.  “Indy” is a major shipping hub with a good, but extensive highway system.  I-465 circles the metro area while I-65, I-69, I-70, and I-74 all tie into it, along with several U.S. highways.  The speed limit is 55 MPH and most drivers seemed to obey it, which made for easier urban driving, but there was still a LOT of traffic.

As we got on the north side of town headed west we were looking to exit onto US-31 north.  The GPS told me to exit at Keystone Avenue and turn right onto the relatively new Keystone Parkway, which bypasses the initial stretch of US-31 before joining it some miles farther north.  Fortunately I spotted a sign before exiting the highway that said vehicles over 19,000 pounds GVW were not allowed on the Parkway.  Also fortunate was that I knew the exit for US-31 was only a couple of more miles ahead and was a perfectly acceptable place for us to get off of I-465.  I had not been this way in a while and discovered, to our pleasant surprise, that it is a completely new, limited-access highway heading northbound.  Sweet.

We handled the situation smoothly and without too much consternation, but it was concerning that our GPS tried to direct us onto a road for which we were too heavy by more than double.  That had us wondering if the RV characteristics parameters were not set correctly, and perhaps got reset when I updated the unit while we were at Florida Grande Motor Coach Resort, but now was not the time to check all of that.  This is a relatively recently rebuilt roadway, and it was been my experience with both GPS units that the map updates do not include these newer roads.

Another possibility was that the Indiana Highway Department has not updated the state road database as that is where Rand-McNally (and other mapping companies) get the information for their road maps.  I encountered this a while back when traveling US-24 from Peru, Indiana to Defiance, Ohio.  Even though my GPS database was up to date, it had no knowledge of the new construction between Ft. Wayne, Indiana and Defiance.  The same us still true of the new stretch of US-31 running south from US-20 for many miles even though it has been open for quite a while.  The State highway departments are responsible for updating the database that the GPS/mapping companies use.  If they do not update the database there isn’t much the GPS/mapping companies can do.

Indiana has made major improvements to US-31 over the last 3 to 4 years, building whole new limited access sections.  Besides the section coming south from US-20 and the section going north out of Indianapolis, there is one that now bypasses Kokomo.  The older sections are four lane divided but have grade crossings and occasional traffic signals.  They are posted at 60 MPH and traffic is usually light and moves along well.

All-in-all we had an easy final leg from Indy up to State Road 16 and west into Twelve Mile.  At 11 AM, just 3-1/2 hours after we pulled out of the Clarksville KOA we were back in Twelve Mile again.  We pulled into the gravel driveway for the grain elevator, which is not in use this time of year, to unhook the car.  The driveway is exactly opposite where I park the bus when it is here and positions me to basically back across SR-16 into our spot next to Butch and Fonda’s bus.  Linda spotted for me as I backed across SR-16 and into our spot.  I leveled the coach, shut off the engine, and took care of the exterior arrival tasks while Linda took care of the interior ones.

Butch and Fonda did not come out of the house and we were not sure they were home.  We usually have a very poor Verizon signal when the bus is parked in this spot, and today was no exception, but I was able to get our Verizon Mi-Fi online.  About that time Butch and Fonda came out to check on us and we visited for a while.  We had not knocked on the door because we knew there was a possibility they might not be home when we arrived.

Butch needed to be at a local county fairgrounds at 5 PM to help set up a large room for a hamfest tomorrow.  Fonda was reviewing for the General Class license exam, so Linda studied her Amateur Extra Class flash cards with Fonda while Butch and I went to the do the set up.  The hamfest was an annual joint event put on by four county amateur radio clubs.  After the tables were all set I helped Butch carry in all of the stuff from his truck and arrange it on three adjacent tables.  When we were done, and there was nothing else to do, we returned to Twelve Mile.

It was 6:30 PM by the time we got back and we decided to go out for dinner even though the options for us are very limited.  We drove to Rochester hoping to eat at a Mexican restaurant but it was closed (permanently).  We ended up at Tweedle Dee’s instead, mostly because they have a salad bar.  We were the last diners to leave and only then because they needed to run the vacuum cleaner which cut off any chance of Linda hearing any further conversation.  We stopped at Butch and Fonda’s new (to them) house on IN-25 in Metea but Butch did not have the key with him so we did not get to go inside.

By the time we got back to Twelve Mile we were all tired.  Butch and Fonda had to be up very early to go to the hamfest so they signed their tax returns, got them ready to mail, and brought them to our bus for Linda to mail in the morning.  I planned to go to the hamfest too, but not first thing in the morning.  I also wanted to take our car so I could come back to Twelve Mile before the hamfest ended at 1 PM.

Our series of equipment failures seems to be continuing as I was unable to get the Amped|Wireless SR20000G router/network-extender to recognize any hard wired devices.  I tried plugging in both my computer and our NAS to all five of the ports but none of them responded to either device.  It’s unlikely that the wired networking had failed on both the computer and the NAS so the failure of the SR20000G is the more likely cause.  The SR20000G’s wireless networks are still working but the loss of the wired ports means I cannot access the NAS.  Fortunately we will be home in a few days and I can try to sort this out in the comfort of my office.

Being tired, and with no TV reception, we were in bed by 10:30 PM and I was asleep by 11 with no alarm set for the morning.

 

2016/04/01-05 (F-T) J-P-Shuffle CCAFS Farewell Celebration

Leave a reply

2016/04/01 (F) The J. P. Shuffle

Linda was up before me and got to see one of the cruise ships come in at 6:20 AM.  She said it was all lit up and quite a sight.  I got out of bed at 8:20 AM and made coffee.  Linda prepared toast and jam for breakfast and gave each of us half of an orange.

I finished up my post for yesterday, worked on this one, and then noticed that an iOS 9.3.1 update was available for the Apple iOS 9.3 update that I installed Wednesday evening and Linda installed last night.  It was only 18 MB but still took a long time to download and install.

Today was April Fool’s Day and time for us to once again do “the Jetty Park shuffle.”  I have checked at least once, and often twice, each day to see if an appropriate full hookup site had become available through cancellation for Friday, Saturday, and Sunday nights, but it had not.  Around 10 AM I walked to the office to check one last time.  Scott Ward was the JP staff person on duty and was very helpful but a site was just not available.  He was able, however, to put us on site #357 for Sunday, Monday, and Tuesday night’s.  I shortened our stay on site #3 to two nights and paid the balance for the one night.

Site #3 is a water only site, no electricity and no sewer connection, and the rules say that NO pets are allowed in that section, which is right along the channel and outside the regular fenced campground.  The staff was aware, however, that we have two cats onboard and let us have the site anyway.  We do not ever want them to escape, but especially here.

Our generator can produce more power than we can get from a “50 Amp” RV electrical connection, so not having electricity is not really a problem.  The only real downsides, other than having to move, are that we can feel, hear, and sometimes smell the generator.  We also had a problem with a circuit breaker for its cooling fan last winter.  I made a temporary fix to it but have never fixed it permanently.  We also do not like to leave the genset running when we are away from the coach, such as will be the case on Saturday morning.

I selected/processed three photos of the manatees we saw on Tuesday at Merritt Island National Wildlife a Refuge and e-mailed them to Pat and Vickie.  I then replied to a couple of e-mails from Gary at Bus Conversion Magazine.  By this time it was 11 AM so we prepared the bus, inside and out, to be moved.  With all of the Windows and roof vents closed it warmed up quickly inside even with a lot of the coach in the shade.  When I turned the ignition key the engine turned over but would not catch and my heart just sank.

I really like this bus, but I have grown weary of the uncertainty of whether things will work when needed.  I turned the ignition key off and rechecked the transmission selector and parking brake settings.  I also switched the suspension out of Level Low to drive mode although that should not have mattered.  With the ignition key turned to the ‘ON’ position the 12 V chassis battery seemed a little low and a red light flashed a few times on the transmission selector, so I turned the key off, went to the outside battery disconnect switches, and turned both the 12V and 24V disconnects off and then back on.

Back in the driver’s seat I tried again.  Normally the engine only turns over a few times before it fires.  This time I let it turn for four or five seconds and it finally started.  If I had any sense I would have driven it to the W. W. Williams Detroit Diesel service center in Orlando, but I moved it to site #3 at J. P. instead.

Our coach in Site #3 at Jetty Park & Campground, Cape Canaveral, FL. This is the “water only” camping by the shipping channel. All of these rigs are parked facing north towards the channel. It’s a great spot to watch the ships come and go.

To get from site #358 to site #3 I had to exit the fenced campground and drive around the east end of the park past the beach parking, concession building, and playground and then west along the edge of the shipping channel and around to the back row of the water only sites, all of which face the shipping channel.  As such it was a long drive to get to a site we could see from the one we just vacated.

We left the car at site #358 temporarily and Linda rode along in the bus.  I made the whole trip in 1st gear, to keep the RPMs up, and turned on the OTR A-C, both to cool the interior of the coach and to put more load on the engine and help get it up temperature.  I did not pull the tag axle up as we had walked the park/campground enough to know that I did not need to make any really tight turns.  When I was mostly into position on site #3 Linda got out and spotted the final position of the rear end.  These channel-side sites slope down towards the channel (facing north) and the back row sites get steeper the farther off the back off the site you go.  I wanted to pull forward just enough to get our tow bar clear of the access road behind the site and Linda accomplished that with an inch or two to spare.

I left the engine running and switched it to high idle to run the OTR air-conditioning.  While Linda went back to get our car I got out the step stool and awning pole and deployed all four awnings.  I then started the Genset to make sure it was going to run and produce electricity.  I also thought we might run the residential air-conditioners.  When Linda returned with our car she wanted to open up the coach so I shut off the OTR bus A-C, dropped the engine idle to low, and let it idle for a couple of minutes before shutting off the engine.  I left the genset on for the time being.

Both of our systems had been reacting to what we had eaten the last few days so we passed on lunch and just hung around our new site which was, in fact, very pleasant with a view of the water in the channel and the high ground of Cape Canaveral Air Force Station on the opposite bank.

Our driver side neighbors stopped to chat on their way to the beach and let us know that they had just spotted dolphins in the channel.  I walked over and caught a glimpse of several arching repeatedly out of the water but by the time Linda got there they had submerged and not resurfaced.  Given where we are parked we should have a good chance to see dolphins and view cruise ships coming and going from the Port.

Linda made a cold garbanzo bean salad for dinner last night.  After dinner I was trying to get us connected to the park Wi-Fi system but could not maintain the connection or get us logged in.  I tried using our Verizon Mi-Fi but could not get the WiFi Ranger to work with it.  I tried to reconfigure the Amped|Wireless router to work directly with the Mi-Fi but there were problems with that as well.  At one point my ASUS notebook computer decided that it could not detect any Wi-Fi networks even thought it had two of them sitting within a couple feet of it.  I got disgusted with the whole situation, shut everything off, and we went for a walk.

Linda waves to the Disney “Magic” cruise ship as it heads out to sea from Port Canaveral, FL. There is always a crowd along the channel to wave the cruise ships in and out.

We walked over to Pat and Vickie’s coach and Vickie joined us.  We headed to the beach where we enjoyed a very brisk breeze until lightning to the southwest signaled that it was time to return to the safety of our rigs or one of the park buildings.  We headed back past the playground area towards our coach and Vickie split off for the gate in the campground fence that provided the most direct access to her site.

Back at our site we closed up the coach against the humidity and coming storm.  I then started the auxiliary powerplant (genset) and turned on the air conditioners.  Not long after that it started to rain, lightly at first, but it eventually became very heavy for a while before finally moving offshore.

With the A-C’s running I was reminded that I need to change some of the AC circuits in the main panel.  The front and middle air-conditioners are on different legs of the AC power system, front on L1 and middle on L2.  That makes sense as we would normally want to run both of them at the same time to cool the front half of the bus (living, cooking, office space) when we are awake and using the bus.  The 3rd/bedroom A-C has to go on one of the two legs and either one could create load balancing issues.  Unfortunately, the middle A-C unit is not currently producing any cooling.

To make matters worse, the charger section of our Magnum 4024 inverter/charger also draws its power from L1.  Again, it had to go somewhere, but the current configuration tends to put too much load on L1 and not enough on L2.  Even though the genset is oversized for our electrical needs an imbalance between L1 and L2 is still a problem because it is set up as a 240 VAC unit with a 240 VAC voltage regulator.  Although it has an active neutral, allowing it to supply 120 VAC to both L1 and L2 (180 degrees out of phase) the regulator is only concerned with maintaining the 240 VAC between the two legs, not the 120 VAC between each leg to neutral.

If the loads on the two legs are not reasonably balanced, the 240 VAC will “drift” off center from neutral with the voltage on the high load leg dropping and the voltage on the low load leg rising.  That, in turn, can/does cause havoc with some of the devices onboard, especially the microwave oven, APC uninterruptible power supply that powers the Amped|Wireless router, and the APC line voltage stabilizer that powers the laser printer.

We were, however, able to watch TV and found Ken Burns’ JAZZ documentary on channel 24.1.  By 11 PM we needed to get to bed as we had to be up and ready to go by 7:45 AM tomorrow morning.  I turned the genset off around 11:30 PM and let the house electrical system switch to the inverter.  I tried to watch the end of JAZZ on the TV in the bedroom but the TV and antenna controller kept losing power.  That, in turn, caused the TV to shut off and the controller to reset to position 8.  My phone and iPad chargers, both of which were plugged into AC outlets, also kept cutting in and out.

I encountered this same issue when we were boondocking at John Palmer’s place in Mayo, Florida at the end of November 2015.  At that time I turned off the SEARCH WATTS feature thinking that it was causing the problem.  Apparently that was not the problem.  My best guess is that under very low load conditions the inverter is either:  a) not inverting at all, or b) producing a voltage and/or current that is not well regulated.  In either case, it would play havoc with our entertainment and communications electronics.

Rather than screw around with this anymore tonight I gave up , turned off the TV, unplugged the antenna controller, resolved to ignore the device chargers, figuring they would work when the refrigerator or air compressor ran, and tried to fall asleep.  I could have turned on the AC lights in the living room, or our small portable fan, to draw enough AC current to keep the inverter working, but that’s really contrary to the whole notion of minimizing your energy usage to only those things that are absolutely necessary when running on batteries.

2016/04/02 (S) Cape Canaveral Lighthouse Tour

I was awake at 6 AM and we were both up and dressed by 7 AM.  I did not make coffee or have breakfast and Linda just had a piece of bread as making toast would have required me to start the genset.  The batteries were at roughly 24.6 VDC (and showing 72% SOC) with no load being drawn by the inverter so there was no need to recharge them this morning.  We were due at Pat and Vickie’s coach at 8 AM so I gathered up my camera, holster, and extra batteries.  We left at 7:40 and took our time walking over to their site.

Pat and Vickie have seating for four in their Jeep Grand Cherokee and have been providing transportation for our group outings.  We left just after 8 AM for the short drive to the Exploration Tower at the west end of Port Canaveral.  We signed up for a tour of the Cape Canaveral Lighthouse that departed from the Tower at 8:30 AM and included admission to the Tower when we returned.

There were only twelve of us on the small tour bus plus a driver (Mike) and two tour guides.  The Cape Canaveral Lighthouse is located on the grounds of the Cape Canaveral Air Force Station (CCAFS).  One of the tour guides (Jim) had worked at the Station and was our main guide for information about the Station and the various launch sites we visited; and we visited a number of them.  One of the things we learned was that CCAFS is a Station rather than a Base because no one lives there.  All of the Air Force personnel working at CCAFS are from Patrick Air Force Base, which is located south of Cocoa Beach.  The U. S. Navy also has a presence here with facilities that service ICBM and attack submarines.

The Cape Canaveral Lighthouse located within the Cape Canaveral Air Force Station, FL.

The Lighthouse had its own cadre of docents, and was very interesting to see and learn about, but only accounted for a little less than an hour of a 3-1/2 hour tour.  The other tour guide was Ron and he provided most of the information about Port Canaveral.  Just after exiting CCAFS we visited a small museum devoted to the history of the Station.  It was located next to the building that now houses the launch control facility for SpaceX, the commercial spaceflight venture of Elon Musk of PayPal.  There are other private/commercial companies operating at CCAFS besides SpaceX .  One of the largest is United Launch Alliance (ULA), an independent company that was formed by merging the space operations of Boeing (which absorbed McDonnell-Douglass years ago) and Lockheed-Martin.

All that remains of one of the launch pads at CCAFS, FL.

We did not really understand ahead of time what we were going to see and we were surprised by the dilapidated condition of the old launch sites.  All that remains at most of them are concrete and brick works.  Metal superstructures that were subject to rusting were long ago removed and control centers that were once stuffed full of equipment are now “abandoned in place” or used for storage.  It was like visiting an ancient historic site, which in fact it is; the first rocket launched from this site was a German V-2 in 1950 and the Mercury missions occurred in the early 1960’s over 50 years ago.

A continuation of the previous image, this is the command bunker and tunnel. CCAFS, FL.

Back at the Exploration Tower, which is owned and operated by the Canaveral Port Authority (CPA), we got wrist bands good for admission through closing time today.  The weather had been overcast all day and a check of the radar on our smartphones showed heavy rain moving our way.  Even though we were hungry we decided to experience the Tower before the rain moved in.

This is all that is left of what was once a heavily reinforced HVAC building at the launch pad. The superstructure in the distance is in active use by SpaceX and ULA. CCAFS, FL.

The Exploration Tower has seven floors plus additional structure at the top.  We took the elevator to the top floor which features an outdoor observation platform oriented to give a commanding view of Port Canaveral, CCAFS, and the John F. Kennedy Space Center to the north, as well as the Banana River to the west and the Atlantic Ocean to the east.  There are also views to the south of the cities of Cape Canaveral and Cocoa Beach.  We took the stairs down to each floor in turn.  Each floor has a theme with related exhibits and we stopped at each one.  The 3rd floor is a small theater that shows a 20 minute film about Port Canaveral and the surrounding area; past, present, and future.  The film starts on the hour and half hour so we caught the 1 PM show.  The second floor is a balcony that affords a view of art hanging above the 1st floor lobby and gift shop.

The Exploration Tower at Port Canaveral, FL. The top floor includes an outdoor observation deck.

Back on the 1st floor I bought two coffees while Linda and Vickie shopped for gifts.  Linda found a stuffed toy of a manatee for our grand-daughter Madeline.  When we finally got back to Jetty Park at 2 PM Linda made sandwiches for lunch and I washed off some grapes.  I checked the house battery bank voltage and it was still OK.  The temperature had cooled off under cloudy skies with a strong southerly breeze, so I did not need to run the air-conditioners.

I took a nap for an hour.  Not long after I got up we noticed activity in the shipping channel so I took the camera and we went out to see what was going on.  We set up two chairs in front of the bus to watch the action.  The blue tug boat was hanging around the entrance to the Trident Turning Basin, which we had not seen it do before.  The Brevard County Sheriff boat came out along with one of the harbor pilot boats.  A U. S. Coast Guard boat, with a large caliper machine gun on the bow that was manned, headed out the channel towards the ocean at high speed.  We thought perhaps we were going to get to see a submarine arrival, which are always unannounced, but the reason for all this activity turned out to be the Carnival Cruise Ship “Valor” coming into port.  It was delayed from its scheduled arrival by almost 12 hours but that worked to my advantage as the cloud cover had thinned and provided nice lighting on the bow of the ship as it traveled west into the channel.

A 180 degree panorama, from west through north to east, from the observation deck of the Exploration Tower at Port Canaveral, FL.

A little while later the Norwegian Cruise Line “Spirit” left its dock and headed for the Atlantic Ocean accompanied by the police, Coast Guard, and harbor pilot boats.  About 20 minutes behind the NCL Spirit, the Disney “Fantasy” left its dock and started its slow trip down the channel.  Vickie showed up before it got to our position and had her iPad with her.  As the boat came abreast of our position, Vickie spotted dolphins swimming just in front of the bow.

I got out another chair and we sat in front of the bus and chatted for a while.  Vickie eventually returned to her coach to fix dinner and we went inside.  I transferred today’s photos to my computer and selected two to process and send to Vickie.

A dolphin swims in front of one of the Disney cruise ships as it heads down the channel from Port Canaveral, FL. towards the sea.

For dinner Linda improvised a potato and broccoli dish with onion, garlic, and couscous.  It was light and very tasty.  After we were done eating I texted Vickie.  They were also done with dinner so we met her at the office and went for a walk.  Back at our coach Linda checked online and found a news story about the Carnival Valor.  The Valor was delayed due to a medical situation that required them to return to the Turks and Cacos.  According to CruiseTimeTables.com, passengers were being advised to embark starting at 9 PM and to be onboard by 11 PM, with departure shortly thereafter.

Back at our coach we watched some TV and waited up for the Carnival Valor to leave as the nighttime departures are rather something to see with the ships all lit up.  Linda waited until midnight and then turned in for the night.  I stayed up until 1:30 AM but it was still docked at the west end of the port so I gave up and went to bed.

2016/04/03 (N) Bon Voyage

I was waiting for the Carnival Valor to leave Port Canaveral last night but by 1:30 AM it was still at its terminal.  It was all lit up but going nowhere, so I finally went to bed.    By midnight the skies had begun to clear and the wind, which had been steady all day, became stronger and started shifting around to the northwest and becoming noticeably cooler.

The cruise ships are particularly magical at night and I had hoped to capture some images of them, having set my camera to SCeNe selection mode (SCN) and selected “Night.”  In spite of being up late I did not sleep soundly and was aware of headlights around 5 AM.  Someone had apparently driven over from the campground to watch ships, or perhaps driven into the park, which opens at 5 AM, for this purpose.  I then noticed a ship in the shipping lane heading for the mouth of the channel.  Around 5:30 AM another cruise ship came in.  I got up, put on my robe, and tried to photograph it from the cockpit of the bus.

The nighttime arrival of the Carnival “Victory” cruise ship at Port Canaveral, FL.

I got up to stay a little after 8 AM and started the genset so I could make coffee and heat water.  Linda got up shortly thereafter and prepared our breakfast cereal.  We could see cruise ships docked at the west end of Port Canaveral so Linda checked the CruiseTimeTables.com website, and found that there were four cruise ships scheduled to depart today; three at 4 PM (the Carnival Sunshine and Victory, and the Royal Caribbean Freedom of the Seas) and one at 4:30 PM (the Disney Magic).

The Magnum ME-ARC indicated the house battery bank was at 24.6 VDC and 69% SOC.  I turned on the genset and the charger started in Bulk Charging mode drawing 110A at 24VDC, or just over 2,600 Watts, on L1.  I turned on the Aqua-Hot electric heating element, which is on L2, to balance the load on the genset a bit.  When the battery charger had backed off a bit and switched to Absorption mode I turned on the block heater for the main engine, which is currently on the same leg (L1) as the charger.  Balanced loads lead to balanced voltages, but it is also better for the genset mechanically to run under a somewhat heavier load than a light one.

Around 10 AM I walked over to check site #357.  It was already vacant so I went to the office to confirm that we still had it reserved for tonight through Tuesday night.  We did, so I told the office clerk that I was going to go ahead and move, if I could get the engine started, and would then come in and register.  If I couldn’t get it started I would extend our stay on site #3 until we could get the problem resolved or get it towed.  The clerk was not particularly sympathetic, but then he was the one who would have to deal with an irate customer who could not have their reserved site, and the people who camp here have very particular preferences about their sites.  Fortunately, site #3 was open so we could have stayed there until we needed to dump our holding tanks.  We could minimize water usage by using the campground bathrooms, so we could have stretched our dry camping if needed.

Back at our rig we started preparing to move it.  I moved the car over near the pedestrian gate that is very close to site #357 and walked back to the coach.  Linda had secured the inside enough for the short, slow trip.  I checked the maintenance chargers for the chassis batteries and they indicated 100% charge levels.  I opened the air supply valve for the engine accessories, engaged the 12 and 24 volt chassis battery disconnect switches, pulled the wheel chocks, and put the entry step stool away.  I put the Level Low system in Drive mode, just in case that mattered, and turned the ignition key.  The bus motor cranked quickly and fired right up!  That was a relief.

The Centurion Battalion of the United States Navy Sea Cadet Corps had arrived at the picnic area sometime before 8 AM with a large contingent of cadets and their adult leaders/chaperones.  And they had arrived in a large number of cars that filled the available parking spaces just on the other side of the road that ran behind the back row of RV sites where we were parked.  There was still plenty of room to back out, but Linda positioned herself outside to keep an eye on the back end of the rig.

The motorhome on our passenger side was also ready to leave and backed out before I did.  I don’t think he would have presented an obstacle, but having him gone was one less thing to have to keep an eye on.  I pulled up the tag axle and then pulled forward to the right to position the coach at an angle to the road behind it.  I then backed up and cut the steer tires hard left to swing the nose around to the passenger side and guide the rear end cleanly into the road well clear of any other vehicles.  Linda climbed on board and I turned on the OTR A-C, partly for comfort and partly to put more load on the engine.

We made the 5 MPH trip around the east end of the park and campground back to the campground entrance on the south side where Linda got out to open the gate.  Once I was clear of the gate she got back onboard.  We wound our way through the campground, familiar now with the road system.  When I got to the 2nd to last turn I saw that the last turn was blocked by a pickup truck pulling a 5th wheel trailer out of its site so I continued straight ahead and went clockwise around Red Knot Circle.  By the time I got back to the same intersection the pickup truck and 5th wheel were out of the way and I was able to proceed to site #357.

Linda hopped out to act as spotter.  Using what I learned two years ago from Big Bill while getting parked at Suncoast Designers in Hudson, Florida I moved to the right edge of the road as the back-in site was on that side.  As I pulled past the site and the rear wheels were by the front of the site I cut the steer tires to the left, positioning the coach at an angle to the site, all the while avoiding trees, RVs, cars, and other obstacles.  I backed straight, keeping an eye on Linda in the driver side rear view mirror, and started swinging the nose to the driver side while keeping an eye on the car parked on the other side of the road.

As soon as I was clear of that car I swung the nose hard to the driver side.  We were well clear of the Sea Grape trees on the passenger side so I straightened the steer tires and pulled forward until I had a good view of the concrete pad on one side.  I backed in following Linda’s hand signals until I could see the pad on both sides, got the rig straight and centered, and backed up until Linda gave me the stop signal (arms crossed at the wrist above her head).  We ended up parking with the front tires just off the front edge of the concrete pad as the coach was close to level and we wanted to avoid lower branches at the rear of the site.  As it was, I still had to lower the front slightly, but at least the Level Low system worked this time.  I also had to adjust the rear on one side, which worked a lot better after I lowered the tag axle.

With the coach neatly tucked in to its site and sitting level Linda walked the short distance back to where the car was parked and drove it around to our site.  Once the car was parked I walked to the office and took care of the registration.  When I got back I tried to get our network up and running but encountered all sorts of problems.  I wasted most of the rest of the afternoon trying to resolve them, to no avail.

While we were camped on site #3 I had to reconfigure the Amped|Wireless router/range-extender to work directly with our Verizon Mi-Fi.  That configuration worked OK out there, but was not working here.  The Wi-Fi ranger was seeing a number of campground Wi-Fi signals with adequate to very good signal strength, but was having a very difficult time connecting to them.  When it did, the connection would drop after a very short time.  The Amped|Wireless router/range-extender was having an equally difficult time connecting to the Wi-Fi Ranger and staying connected when it did.  I tried connecting the Wi-Ranger to our Verizon Mi-Fi but that did seem to work either.  I also noticed that the cellular signal was not as strong as usual.  Linda commented that her phone was having trouble connecting.  I finally got disgusted with the whole thing and set it aside.  Sometimes the best solution is to “just walk away.”

There were four cruise ships starting down the shipping channel roughly on time and in the order specified and Vickie joined us for the ship parade.  We were out there waiting for them, camera at the ready, and by the time the last ship was headed out to sea I had shot about 200 images.  Vickie had already eaten, and we were not ready for dinner yet, so we walked the campground and park, including the pier.

It was chilly all day yesterday with a high temperature in the low 70’s and a steady breeze from the north that resulted in a hazardous conditions warning for the beach.  As the light faded it got colder and we returned to our motorhomes.

Dinner was a nice salad and Amy’s enchiladas.  Simple, easy, tasty.  It turned colder after sunset under clear skies and a stiff northerly breeze.  It was very refreshing, initially, but eventually the coach was a bit too cool so I closed the roof vents and Linda narrowed the window openings to just an inch.  We were a little tired, not particularly captivated by what was on TV, and had to be up earlier than usual in the morning, so we were in bed before 11 PM.

2016/04/04 (M) Farewell For Now

It turned chilly after sunset last night under clear skies and a stiff northerly breeze.  It was very refreshing, actually, but eventually the coach felt chilly and we closed it up, mostly, and were in bed a bit earlier than usual.

We were up at 7 AM this morning and got dressed right away.  I made coffee, which used up our supply of Sweet Seattle Dreams beans, and we headed over to site #303 at 7:30 to see Pat and Vickie off.  They have been here since mid-February and today was departure day.  The bus motor was already running when we got there and we just watched while they got ready to pull out.  We learned long ago not to “chat” with RVers during their final departure preparations.  They drove around by the office to hook up their car and we walked over to watch.  I took a couple of pictures with my phone and used the “dawn” setting for the first time.  Soon enough they were ready to go, so we said our final “farewells for now,” and, just like that, they drove off and were gone.  Assuming no mechanical or weather issues they will be home in northern Indiana Wednesday evening.

A group of five brown pelicans coming up the channel just above the water. Jetty Park at Port Canaveral, FL.

We always find that leaving an encampment after we have been there for an extended period of time has a strange feeling and we experienced that vicariously as Pat and Vickie drove away.  The strangeness, as best I can describe it, is a combination of a sense of loss—the giving up of a familiar place and the people there—and anticipation of the journey ahead, both positive and negative.  The anticipation is positive in the sense of the possibilities of new experiences that come with the adventure of the road while the negative anticipation stems from the potential for mechanical, weather, traffic, or health problems.

With Pat and Vickie out of sight we returned to our coach and had a light breakfast of toast and jam and finished our coffee.  Linda then worked on a grocery list while I tackled out networking problems.  I gave up in disgust around 10 AM and we drove to Cocoa Beach to do some grocery shopping.  We went to the Publix supermarket first and found most of what we needed there.  A quick stop at Sunseed Food CO-OP filled in our list with blueberries, coffee, and vegan mayonnaise.  I stopped at one of the Shell stations on the way back to J. P. and topped off the fuel in the car so we would not have to deal with that tomorrow morning.

Back at our coach we got the groceries unloaded and put away.  Linda then heated some leftovers for lunch and washed some grapes.  After lunch I put in a call to Chris Yust, our National General Insurance Agent, to ask her about the letter/form we received regarding Coordination of Medical benefits.  She called back a short time later and we discussed it.  She logged into her agent support system but there was no indication of the letter/form.  Normally she can see anything the insurance company has sent to her customers.  She confirmed that we really did need to send the form in with the requested documentation.

Linda had already photographed the fronts and backs of our MPSERS/BCBS cards.  When she tried to print them the printer was “offline”.  We had this same problem at the beginning of our winter travels and it turned out to be NETWORK related.  The fix back then was to use the Advanced IP Scanner to determine what IP address was assigned to the printer and then manually reconfigure the printer to that address.  That was under Windows 8.1.  Under Windows 10 the IP Scanner didn’t work the same way and the manual reconfiguration didn’t work either.  What is particularly puzzling and annoying is that the printer does not appear to be responding correctly when set as a DHCP client.  If it was, we would not be having a problem communicating with it.

I seem to have spent a lot of time this past week dealing with network and wireless communications malfunctions, so I did what I often do and we went for a walk at 2:30 PM.  We went out on the pier and were just starting back when someone spotted a manatee between the pier and the jetty swimming towards the ocean.  The water was clear and we got a good look at it for quite a while.  It was large and presumably a full-size adult.  They really are gentle giants and it was a thrill to see it.

We walked back to the office for coffee before returning to our rig.  As soon as we went in Scott Ward handed Linda a card.  She has not been in the office that much but I have, and have often interacted with Scott while checking on, or registering for, sites.  Still, I was impressed that he remembered my last name and made the connection to the card.  The card was from our younger grand-daughter, Madeline.  It was a ‘thank you’ card for Linda for all of the custom photo postcards she has created using the PhotoPostCard app and had printed and mailed to Madeline by the PhotoPostCard service out of San Diego, California.  Linda took a picture of the card, texted it to our son, and asked him to tell Madeline “thanks” in return.  He texted back a photo of Madeline looking at the most recent postcard, which was a photo of Linda by the channel with one of the Disney cruise ships heading out to sea.

The Royal Caribbean Enchantment of the Seas was due to sail at 3:45 PM followed closely by      the Disney Dream at 4 PM.  We walked over to the shipping channel at 3:40 PM and by the time we got there the Enchantment was starting to move away from its dock.  Something did not look right and then I realized we were looking at the stern of the ship.  The cruise ships usually dock facing the ocean, so it needed to turn around to get out of Port Canaveral.

One of the amazing things about these amazing machines is their ability to maneuver in close quarters.  When in port, they can independently push the bow and stern to either side, which means they can move sideways or turn the ship around its center (or any other point).  In this case they pushed the stern out from the dock on the south side of the channel and into the opening of the middle turning basin on the north side of the channel opposite the dock.  They then backed it up slightly into the turning basin, brought the bow around into the channel, pushed the stern out into the channel, and then started moving forward down the channel towards the ocean.  It was quite a skillful maneuver and the first time we have seen this in the two weeks we have been here.

Not long after the Enchantment cleared the Jetty and turned southeast to stay in the channel, the Disney Dream started moving slowly forward and away from its dock.  The Disney terminal/dock is in an alcove (basin) on the north side of the west end of the Port so it has to turn into the straight portion of the channel.  Of all the cruise ships we have seen come and go the Disney ships appear to be in the best condition, not that any of them look bad.

We returned to our coach and I transferred photos to my computer from the camera and from my cell phone while Linda started preparing dinner.  Dinner consisted of a kale salad followed by a brown rice and kale dish with sautéed carrots, onions, and garlic.  Linda has not had any wine in a couple of weeks because of the medications she’s been taking, but I had a glass of the Arbor Mist Raspberry.  I find “flavored” wines a questionable choice, although I like Sangria and hot mulled or spiced wine.

We went for a walk after dinner that included some time on the beach.  The park and beach were a beehive of activity yesterday but things were quiet all day today and there were only a handful of people on the beach this evening.  Both conditions are nice, in their own way.  There was, however, some activity in the Trident submarine turning basin today.  The big crane was moving and a Coast Guard cutter was in and out of the basin.  An attack helicopter from Patrick AFB also made repeated passes over the area and up/down the beach.  Our friends told us that when things start getting active around the basin it usually means a submarine is coming in but that did not happen while we were watching.

Back at our coach we turned on the TV but all of the CBS programs were repeats because the NCAA Basketball final game was on cable.  I reconfigured the Amped|Wireless router to work directly with our Verizon Mi-Fi and was able to get my computer connected to the Internet and to our NAS, which is critical for backing up photos and documents.  I did not, however, mess around further with the printer.  My plan is to move it back into my office at home and leave it there.  I will find a newer one, with better networking functionality, to put in the bus.

We planned to be on the road in the morning between 8 and 8:30 AM so we went to bed before 11 PM.  Linda fell asleep before NCIS-LA ended but I watched the channel 6 news/weather before turning out the lights.  The Cleveland Indians baseball home opener was postponed because of snow on the field and the TV weatherman reported that the average last date for snow in Cleveland is April 18, and for Detroit, April 22.  In spite of a mild winter and early spring, I knew there was a reason we were not in a hurry to return home.  The low at our house was forecast to be 18 degrees F overnight.

2016/04/05 (M) Celebration

We were up at 7 AM, showered, and got dressed.  We tended to our cats and prepared the motorcoach for them to be comfortable while we were away for part of the day.  We each had a banana, and a little orange juice to wash down our vitamins, but did not have a full breakfast or our usual morning coffee.  We gathered up all of the things Linda needed for her doctor’s appointment and were in the car and on our way at 8:10 AM.

Our destination was the office of Dr. Michael Seidman in Celebration, Florida, a trip of 60 to 65 miles from Jetty Park that would take about as many minutes.  Most of the route was Toll Road (FL-528 and FL-417) and we did not have to slow down for the toll booths because we have a Florida SunPass transponder that we can move between the bus and the car.  We put the address of the clinic, which is attached to Florida Hospital, into the GPS.  It accepted Celebration as the city, but the routing showed the destination as Kissimmee.  I didn’t care what it called the place as long as it got us to the correct location.

We left earlier than needed in order to arrive earlier than required and allow for traffic and navigational contingencies.  Less than a mile from the medical center we spotted a Panera Bread Company store and stopped to have bagels and coffee.  While we were there we made use of the free Wi-Fi to update apps on our iPads and smartphones.  We left at 10:15 and finished the short trip to the Florida Hospital complex.  We found a parking spot, found the clinic building, and found the suite for the Head & Neck Surgery Center of Florida (H&NSCF).  Linda had already completed much of the required new patient paperwork so we were there with time to spare.

Sheila, one of the office assistants, got Linda checked in and wanted to know if we had brought copies of her records from Henry Ford Health System, where Dr. Seidman worked for 30 years and treated Linda for the last 20 of those.  I had e-mailed Sheila the day after she asked me to get those records to let her know that HFHS would not send them to another hospital or clinic at Linda’s request and that the H&NSCF would have to request them.  Sheila said she did not receive that e-mail, even though I replied to one she sent Linda.  Oh well, there was nothing to be done at that point.

It was a great relief to Linda to be able to get in to see Dr. Seidman.  Dr. S and his PA, Katherine, carefully went over the history of Linda’s illness and treatment of the last three weeks.  He indicated that the treatment was what he would have prescribed, which was comforting to know.  His routine ENT examination did not reveal any indication of infection or fluid in her “good” (right) ear, which was also good to know.  He really wanted to compare the recent audiological results with her last tests from HFHS so he made a call to someone at the HFHS ENT clinic and was able to get them to fax the test results.  He chaired the ENT department for much of his time at Henry Ford, and that was apparently still worth something with former colleagues.

Dr. S also inserted a scope through Linda’s right nostril and into her throat to exam the areas that cannot be seen any other way.  The scope is a thin, flexible cable with a camera and LED light source at the tip.  The image is fed to a monitor, where I got to see it in real time, but was also recorded so Linda got to see it afterwards.  Her vocal cords did not close completely and were slightly bowed, which Dr. S thought probably accounted for her weak, slightly horse, voice but there was no sign of infection or other pathology, such as tumors.  He noticed that the Eustachian tube opening was “bubbling” which he thought was a good sign.  He also examined the left nostril and did not see anything unusual there either.

All of that was good news, of course, but we were both a bit let down that there wasn’t any additional treatment he could provide at this time.  Direct injection of steroids into the middle ear was still a possibility but he wanted Linda to wait at least four weeks to see if she improved on her own before going down that path.  Equally frustrating was that her hearing, while marginal, was too good for a cochlear implant.  Not that she is eager to have one of those, of course, what she wants is the hearing in her right ear restored to what it was before she got sick a month ago.

Our friend, Mara, was moving her motorhome today from Clermont to Winter Haven and her friend, Michael, was driving to Orlando International Airport to drop off a rental car and fly back to Phoenix, Arizona.  They had hoped to do all of that by way of Celebration and have lunch, with or without us, at Ari, a Japanese sushi restaurant.  We had indicated that it was very doubtful we would make it to lunch, given the timing of Linda’s appointment, but called Mara when we got back to our car to update her.  It turned out that when she got ready to leave her motorhome slideout would not slide in.  (I think that’s why they are called slide “outs.”)  Michael returned home as planned while Mara arranged for a technician to fix her non-sliding slideout.

We needed to fax a few documents to National General Insurance Company, so we went in search of a Staples with a copy center.  Having taken care of that we wanted to have lunch before heading back to Cape Canaveral so as not to be eating dinner too late in the day.  We found another Panera near FL-417 and Orange Blossom Trail and ate there.  The kale-romaine-couscous-almond salad was excellent and the black bean soup was as good as usual.  Well fed, we got on the FL-417 Toll Road and headed back towards the FL-528 Toll Road, which we took back to Cape Canaveral.

We were back at Jetty Park before 2:30 PM and just relaxed for a while.  Around 4 PM we went outside to take care of a few things in preparation for our departure tomorrow.  I got out the waste drain hoses and connected two of them together to reach from the utility bay connection to the sewer connection, which was inconveniently located directly behind the RV pad.  We drained the waste tanks, rinsed out the hoses, and returned everything to their storage tub.  Using the 3-step stool, I retracted the two awnings on the driver side, which I had previously deployed to shade the Windows from the mid-afternoon sun.

We then emptied out the back of the car so I could add air to the temporary spare, which gave us a low pressure alarm on the drive from Webster to Cape Canaveral.  I had turned on the TireTraker TPMS earlier and most of the readings looked OK, but as long as I had the portable air compressor, hose, air chuck, and pressure gauge out I checked the front right (curb, PS) tire as a check on the TPMS. The tire gauge pressure was several pounds lower than the TPMS indicated pressure and was fairly close to where I wanted it so I left it alone.

Our destination tomorrow was Williston Crossings RV Resort in Williston, Florida, a trip of about 140 miles.  We had about a half tank of fresh water so I did not get out the softener and add any.  Somewhere in the middle of all this work we chatted with several neighbors, but eventually we got the car and bus repacked, including the patio mat and the two bag chairs.  At that point we only had the entry mat, entry stool, and power cord to deal with and the outside would be ready for travel.

Before dinner we went for a walk out by the shipping channel, the pier, and the beach.  There were people out and about but the park did not feel crowded and was quiet and calm, unlike the festive energy of the weekend with its day visitors, picnickers, and family campers with younger children.  It’s as if J. P. has moods, and one has to spend enough time here and experience them to begin to get a sense of the place.  We could understand why Pat and Vickie like to come here every year, even if that is not what we would choose to do.

I could not recall what Linda made for dinner because I am trying to finish this post a week later.  What I do recall is that the Norwegian Breakaway was scheduled to set sail at 9 PM, well after sunset.  It had been a pleasantly cool day with clear skies but turned chilly with the setting of the sun and a noticeable breeze, especially outside the campground by the water.  Linda was tired and a little chilled and chose not to walk out and watch the ship leave.  At 8:45 PM I got my camera, walked over to the channel, and positioned myself by the “Minimum Wake” sign.  I had a good view of the Port to the west and could lean on one of the posts for support if needed.  I put my camera in SCN (scene selection) mode, selected the “Night” setting, and waited.

I had not noticed that the ship was docked with its stern facing the ocean until it started to move.  Its position at the dock meant it would have to do a 180 degree turn before moving down the channel and into the ocean.  And that meant it was going to take longer to exit the port and give me more opportunity to photograph it.

The Norwegian Cruise Lines “Breakaway” doing a 180 degree maneuver in the turning basin. Port Canaveral, FL.

The cruise ships are always brightly illuminated when coming and going in the dark and are quite pretty to see as they glide almost silently by.  They are also challenging to photograph as they are often very high contrast (high dynamic range) subjects, especially at night.  Ideally I would shoot multiple bracket exposures and combine them using HDR software, but I would have to get the camera on a tripod and even then the exposures would be just long enough that the ship would change position slightly between frames.  I did the best I could with single frame, hand-held exposures braced against the sign post.  By the time the Breakaway was in open water I was getting chilled and headed back to the warmth of our bus.  I transferred the images to my computer and took a quick look at them before settling in to watch a few minutes of TV and then go to bed.